Promoting Form II-Form I Phase Transition of Polybutene-1 by Constantly Alternative Annealing

Tang-Guo Liu; Xiang-Yang Li; Shui-Sheng Lu; Yong-Xing Lin; Lin Chen; Xing-You Tian

doi:10.1007/s10118-025-3359-x

Your Location：

Home >

Browse articles >

Promoting Form II-Form I Phase Transition of Polybutene-1 by Constantly Alternative Annealing

RESEARCH ARTICLE | Updated：2025-07-26

- Promoting Form II-Form I Phase Transition of Polybutene-1 by Constantly Alternative Annealing
- Promoting Form II-Form I Phase Transition of Polybutene-1 by Constantly Alternative Annealing
- 高分子科学（英文） 2025年43卷第8期页码：1395-1405
- Affiliations：
  
  a.Key Laboratory of Photovoltaic and Energy Conservation Materials, Institute of Solid State Physics, Hefei Institutes of Physical Science, Chinese Academy of Sciences, Hefei 230031, China
  b.University of Science and Technology of China, Hefei 230026, China
- Author bio：
  
  xiangyangli@issp.ac.cn
- Funds：
  
  This study was financially supported by the National Natural Science Foundation of China (No. 22175183).;Electronic supplementary information (ESI) is available free of charge in the online version of this article at http://doi.org/10.1007/s10118-025-3359-x.
- DOI：10.1007/s10118-025-3359-x
  中图分类号：
- 收稿：2025-02-17，
  
  修回：2025-04-09，
  
  录用：2025-04-15，
  
  网络首发：2025-06-19，
  
  纸质出版：2025-08-01
- Accepted：
Scan QR Code
Liu, T. G.; Li, X. Y.; Lu, S. S.; Lin, Y. X.; Chen, L.; Tian, X. Y. Promoting form II-form I phase transition of polybutene-1 by constantly alternative annealing. Chinese J. Polym. Sci. 2025, 43, 1395–1405

Tang-Guo Liu, Xiang-Yang Li, Shui-Sheng Lu, et al. Promoting Form II-Form I Phase Transition of Polybutene-1 by Constantly Alternative Annealing[J]. Chinese Journal of Polymer Science, 2025, 43(8): 1395-1405.
Liu, T. G.; Li, X. Y.; Lu, S. S.; Lin, Y. X.; Chen, L.; Tian, X. Y. Promoting form II-form I phase transition of polybutene-1 by constantly alternative annealing. Chinese J. Polym. Sci. 2025, 43, 1395–1405 DOI： 10.1007/s10118-025-3359-x.

Tang-Guo Liu, Xiang-Yang Li, Shui-Sheng Lu, et al. Promoting Form II-Form I Phase Transition of Polybutene-1 by Constantly Alternative Annealing[J]. Chinese Journal of Polymer Science, 2025, 43(8): 1395-1405. DOI： 10.1007/s10118-025-3359-x.

摘要

This study reports a new method to promote form II to form I phase transition in polybutene-1. Alternative annealing between ice water and hot water several times can increase the content of form I significantly. Compared to classical two-step annealing

its efficiency is higher

compensating for the shortcoming of the classical method in low-molecular-weight polybutene-1.

Abstract

The slow phase transition from form II to form I has always been an important factor that restricts the processing and application of polybutene-1 (PB-1). After extensive efforts

a set of effective methods for promoting the phase transition rate in PB-1 was established by adjusting the crystallization

nucleation

and growth temperatures. Nevertheless

low-molecular-weight PB-1 (LMWPB-1) faces

challenges because this method requires a low crystallization temperature

which is difficult to achieve during extrusion processing. In this study

we attempted to increase the phase transition rate in PB-1 by changing the annealing temperature after processing rather than the crystallization temperature in the classical scheme. The results indicated that regardless of low- or high-molecular-weight PB-1

repeated annealing between 0 and 90

C could also promote form II to form I phase transition. The initial content of form I increased with the heating and cooling cycles. The half-time of the phase transition (

1/2

) was also shortened after heating/cooling. After 100 heating/cooling cycles

1/2

was reduced to one-quarter of that without annealing

which had almost the same effect as the crystallization temperature at 25 °C in promoting the phase transition. This study indicates that annealing after processing is also an important factor affecting the phase transition of PB-1

and should receive sufficient attention.

关键词

Keywords

references

Gohil,R. M.; Miles, M. J.; Petermann, J. On the molecular mechanism of the crystal transformation (tetragonal-hexagonal) in polybutene-1. J. Macromol. Sci. Phys 1982 , B21 , 189−201..

Azzurri, F.; Flores, A.; Alfonso, G. C.; Calleja, F. J. B. Polymorphism of isotactic poly(1-butene) as revealed by microindentation hardness. 1. Kinetics of the transformation. Macromolecules 2002 , 35 , 9069−9073..

Kaszonyiova, M.; Rybnikar, F.; Geil, P. H. Crystallization and transformation of polybutene-1. J. Macromol. Sci. Phys 2004 , B43 , 1095−1114..

Luongo, J. P.; Salovey, R. Infrared characterization of polymorphism in polybutene-1. J. Polym. Sci. Part A-2: Polym. Phys. 1966 , 4 , 997−1008..

Zhao, Y.; X; Chen, J. Y.; Han, L.; Zhao, L. Nonisothermal crystallization kinetics of polybutene-1 containing nucleating agent with acid amides structure. J. Polym. Eng. 2014 , 34 , 53−58..

Li, Z. Q.; Li, J. Q.; Jiang, S. C. Effects of nucleating agents on the II–I transition of i PB-1. CrystEngComm 2024 , 26 , 1940−1951..

Xu, M.; Han, Y.; Li, X. Y.; Ding, J. J.; Zheng, K.; Lin, Y. X.; Chen, L.; Tian, X. Y. Promoting form I′ crystallization and melting-recrystallization by adding a β -nucleating agent into poly(butene-1)/isotactic polypropylene blends. CrystEngComm 2023 , 25 , 2629−2646..

Valter, S. D.; Costa, C. A. R.; Battirola, L. C.; de Farias, M. A.; Galembeck, F.; Gonçalves, M. D. Polymorphic transformation morphology of isotactic poly(1-butene)/poly(propylene- co -1-butene- co -ethylene) blends. J. Polym. Res. 2017 , 24 , 22..

Wang, Z. F.; Dong, X.; Liu, G. M.; Xing, Q.; Cavallo, D.; Jiang, Q. H.; Müller, A. J.; Wang, D. J. Interfacial nucleation in i PP/PB-1 blends promotes the formation of polybutene-1 trigonal crystals. Polymer , 2018 , 138 , 396-406..

Zhong, Z. X.; Ge, H.; Su, Z. H. Direct formation of form I’ crystals in polybutene-1/polypropylene blend enhanced by cold crystallization. Polymer 2018 , 156 , 30−38..

Zhong, Z. X.; Su, Z. H. Effects of molecular weight on polybutene-1 cold crystallization from polybutene-1/polypropylene blend. Polymer 2019 , 174 , 52−60..

Liu, Y. X.; Li, J. Q. Crystal structures, crystallization and II–I transition behaviors of i PB-1 in i PB-1/UHMWPE blends. Part 1. Crystal structures and crystallization behaviors. CrystEngComm 2022 , 24 , 4093−4105..

Zhong, Z. X.; Su, Z. H. Mechanism of form I′ formation in polybutene-1/polypropylene blends. Polymer , 2022 , 239 , 124469..

Cui, Z. F.; Li, C.; Liu, B. Y.; Jiang , S. C. Retarding crystal transitions of polybutene-1 in blends. CrystEngComm 2023 , 25 , 6144−6151..

Liang, A.; Li, J. Q.; Jiang, S. C. Role of amorphous phase in II-I transition of i PB-1/ i PP blends. Polymer 2024 , 296 , 126818..

Qiao, Y. N.; Wang, Q.; Men, Y. F. Kinetics of nucleation and growth of form II to I polymorphic transition in polybutene-1 as revealed by stepwise annealing. Macromolecules 2016 , 49 , 5126−5136..

Xin, R.; Guo, Z. X.; Li, Y. P.; Sun, X. L.; Xue, M. L.; Zhang, J.; Yan, S. K. Morphological evidence for the two-step II–I phase transition of isotactic polybutene-1. Macromolecules 2019 , 52 , 7175−7182..

Zhang, Z. K.; Xue, Y. H.; Li, R.; Liu, W.; Liu, P.; Ji, X. L. Effect of annealing process and molecular weight on the polymorphic transformation from form II to form I of poly(1-butene). Polymers 2023 , 15 , 800−814..

Li, X. Y.; Ding, J. J.; Zheng, K.; Chen, L.; Tian, X. Y. In situ POM and FTIR investigation o n quiescent phase transition of polybutene-1 from form II to form I. Polym. Cryst. 2020 , 3 , e10098..

Chvátalová, L.; Beníček, L.; Berková, K.; Čermák, R.; Obadal, M.; Verney, V.; Commereuc, S. Effect of annealing temperature on phase composition and tensile properties in isotactic poly(1-butene). J. Appl. Polym. Sci. 2011 , 124 , 3407−3412..

Xin, R.; Li, Y. P.; Guo, Z. X.; Hu, J.; Wang, S. J.; Zhang, H.; Xue, M. L.; Sun, X. L.; Yan, S. K. Influence of initial crystallization temperature of form II on the nucleation and growth of form I i PBu crystals during II–I phase transition. ACS Appl. Polym. Mater . 2021 , 3 , 6666−6673..

Liu, P. R.; Men, Y. F. Glass-transition-temperature-independent form II to I phase transition of low-molar-mass isotactic polybutene-1. Macromolecules , 2021 , 54 , 858-865..

Li, X. Y.; Chen, P. J.; Ding, J. J.; Zheng, K.; Chen, L.; Tian, X. Y. Rapid phase transition of polybutene-1 from form II to form I induced by pressure. Polymer 2020 , 189 , 122169..

Wei, X. Z.; Qu, Y. T.; Jiang, H. W.; Huang, Z. X.; Qu, J. P. Melt-state dynamic pressure engineered polybutene-1 with form I crystals. Polymer 2022 , 256 , 125185..

Lu, Y.; Lyu, D.; Han, C. H.; Yang, X.; Lee, P. C.; Men, Y. F. Crystallization of polybutene-1 into forms I′, II, and III under high pressure CO 2 : in situ synchrotron X-ray diffraction, WAXD mapping, and DSC investigations. Macromolecules 2022 , 55 , 10534-10542..

Wang, W.; Shao, C. G.; Zheng, L. R.; Wang, B.; Pan, L.; Ma, G. Q.; Li, Y. S.; Wang, Y. M.; Liu, C. T.; Ma, Z. Stretching-induced phase transition of the butene-1/ethylene random copolymer: Orientation and kinetics. J. Polym. Sci. Part B: Polym. Phys. 2018 , 57 , 116−126..

Yang, X. K.; Dong, B. B.; Shang, Y.; Ji, Y. X.; Su, F. M.; Shao, C. G.; Wang, Y. M.; Liu, C.T.; Shen, C. Y. Investigation on the phase transition from form II to form I in i PB-1 after pre-stretching. Polymer 2020 , 194 , 122385..

Feng, S. Y.; Zhu, J. H.; Yu, W. C.; Guo, H.; Chen, W.; Lu, A.; Li, L. B. Strain-rate-dependent phase transition mechanism in polybutene-1 during uniaxial stretching: from quasi-static to dynamic loading conditions. Macromolecules 2022 , 55 , 2333−2344..

Wen, S.; Yue, Q. Q.; Liu, Y. J.; Peng, Y. F.; He, A. H.; Nie, H. R. Stretching-induced changes in the crystal structure of isotactic polybutene-1: temperature and stretching speed dependence. Polym. Adv. Technol. 2022 , 33 , 4206−4213..

Li, W.; Zhang, D.; Qv, C.; Zhao, R. J.; Ma, Z. Stretching-induced melting and recrystallization polymorphism revealed in polybutene-1. Macromolecules 2023 , 56 , 2761−2771..

Liu, C.; Zhang, J. Q.; Zhang, Z. J.; Huang, S. Y.; Chen, Q.; Colby, R. H. Shear-induced oriented crystallization for isotactic poly(1-butene) and its copolymer with ethylene. Macromolecules 2020 , 53 , 3071−3081..

Wei, W. K.; Ma, Y. P.; Yan, X. J.; Liu, C. G.; He, A. H. Melt pre-shear induced orientation crystallization of PB and PB/HMwPB blend. Polymer 2022 , 257 , 125276..

Rui J.; Rui X.; Zhang, X. Y.; Li. Y. P.; Yang, H. Y.; Yan, S. K.; Sun, X. L. The shear-accelerated II-I phase transition of isotactic poly(1-butene). Macromol. Rapid Commun. 2024 , 45 , 2400102..

Wang, W.; Zheng, L. R.; Liu, L. Y.; Li, W.; Li, Y. S.; Ma, Z. Stretching behavior of the butene-1/ethylene random copolymer: A direct correspondence between triggering of II-I phase transition and mechanical yielding. Polym. Cryst. 2019 , 2 , e10052..

Liu, Y. P.; Cui, K. P.; Tian, N.; Zhou, W.Q.; Meng, L. P.; Li, L. B.; Ma, Z.; Wang, X. L. Stretch-induced crystal-crystal transition of polybutene-1: an in situ synchrotron radiation wide-angle X-ray scattering study. Macromolecules 2012 , 45 , 2764−2772..

Zhao, R. J.; Liu, Y. Z.; Liu, X. Y; Gao, Y. Q.; Ma, Z. Flow-induced crystallization coupled with strong memory effect: Revealing melt heterogeneity. Macromolecules 2024 , 57 , 7381−7389..

Zhao, R. J.; Liu, Y. Z.; Ma, Z. Flow-induced crystallization starting from self-nucleated precursors. Macromolecules 2024 , 57 , 606−615..

Guo, H. L.; Zhou, C. B.; Zhang, W. Y.; Wang, J. Y.; Li, J. Q.; Shang, Y. R.; Meng, Y. F.; de Claville Christiansen, J.; Yu, D. H.; Wu, Z. H.; Jiang, S. C. Deformation-induced crystalline structure evolutions of isotactic poly-1-butene. Colloid Polym. Sci. 2016 , 294 , 1983−1988..

Lu, Y. G.; Li, H.; Wei, H. X.; Wang, B. H.; Shen, C. Y.; Zhang, B.; Chen, J. B. Influence of melt structure on form II to I phase transition of polybutene-1 under shear flow. Polymer 2020 , 199 , 122562..

Qiao, Y. N.; Yang, F.; Lu, Y.; Liu, P. R.; Li, Y. S.; Men, Y. F. Spontaneous form II to I transition in low molar mass polybutene-1 at crystallization temperature reveals stabilization role of intercrystalline links and entanglements for metastable form II crystals. Macromolecules 2018 , 51 , 8298−8305.

Qiao, Y. N.; Wang, H.; Men, Y. F. Retardance of form II to form I transition in polybutene-1 at late stage: a proposal of a new mechanism. Macromolecules 2018 , 51 , 2232−2239..

Qiao, Y. N.;Men, Y. F. Intercrystalline links determined kinetics of form II to I polymorphic transition in polybutene-1. Macromolecules , 2017 , 50 , 5490-5497..

Liu, T. G.; Li, X. Y.; Lin, Y. X.; Chen, L.;Tian, X. Y. Further promoting form II-to-form I phase transition in low-molecular-weight polybutene-1 by addition of heating/cooling cycles into nucleation stage of form I. J. Polym. Sci. 2025 , 63 , 2010−2024..

Han, Y.; Li, X. Y.; Liu, T.G.; Ding, J. J.; Lin, Y. X.; Chen, L.; Huang, N.D.; Wang, F.;Tian, X. Y. High-temperature relaxation promoting form II-to-form I phase transition of Polybutene-1. Polymer 2024 , 297 , 126893..

Li, J.; Wang, M.; Shi, G.Y.; Liu, G. M.; Wang, L.; Cavallo, D.; Wang, D. J. Cooling condition determines the transition degree at saturation of form II in isotactic polybutene-1 confined within nanopores. Macromolecules 2022 , 55 , 7161−7170..

Ni, L. L.; Xu, S. S.; Sun, C. X.; Qin, Y. N.; Zheng, Y.; Zhou, J.; Yu, C.T.; Pan, P. J. Retarded crystallization and promoted phase transition of freeze-dried polybutene-1: direct evidence for the critical role of chain entanglement. ACS Macro Lett. 2022 , 11 , 257−263..

Han, Y. Study of kinetics and mechanism of the form II to I transition in polybutene-1. Thesis, University of Science and Technology of China , 2024 ..

Cui, X. P.; Huo, J. X.; Lv, T. X.; Hu, C. L.; Li, H. F.; Liu, B. Y.; Jiang, S. C. Chain dimension and crystallization temperature affect the II–I transition of isotactic polybutene-1. CrystEngComm 2022 , 24 , 5711−5723..

Wang, B. H.; He, K. Z.; Lu, Y.G.; Zhou, Y.F.; Chen, J. L.; Shen, C. Y.; Chen, J. B.; Men, Y. F.; Zhang, B. Nucleation mechanism for form II to I polymorphic transformation in polybutene-1. Macromolecules 2020 , 53 , 6476−6485..

Chen, W.; Li, X. Y.; Li, H. L.; Su, F. M.; Zhou, W. M.; Li, L. B. Deformation-induced crystal-crystal transition of polybutene-1: an in situ FTIR imaging study. J. Mater. Sci. 2013 , 48 , 4925−4933..

Fisher, J. C.; Hollomon, J. H.;Turnbull, D. Nucleation. J. Appl. Phys. 1948 , 19 , 775−784..

浏览量

137

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

Liquid Crystal-driven Superspreading of Polymer Droplets at the Air-Water Interface

Spatially Resolved Cavitation within Tensile Stretched Isotactic Polybutene-1 Spherulite

Acceleration of Form II-I Transition in Polybutene-1 by H-shape Long-chain Branching: Critical Role of 1,9-Decadiene as Branching Agent and Synergy with Comonomer

Circularly Polarized Luminescence Based on Helical Polymers: Structure-Property Relationships and Regulation Mechanisms

Durable Anti-fogging and Abrasion-resistant Coatings Based on Polyoxometalates-Hydrophilic Resin Composites with Enhanced Cohesion and Adhesion