Direct Comparison of Crystal Nucleation Activity of PCL on Patterned Substrates

Jian Hu; Rui Xin; Chun-Yue Hou; Shou-Ke Yan; Ji-Chun Liu

doi:10.1007/s10118-019-2226-z

Your Location：

Home >

Browse articles >

Direct Comparison of Crystal Nucleation Activity of PCL on Patterned Substrates

ARTICLE | Updated：2021-02-18

- Direct Comparison of Crystal Nucleation Activity of PCL on Patterned Substrates
- Direct Comparison of Crystal Nucleation Activity of PCL on Patterned Substrates
- Chinese Journal of Polymer Science 2019年37卷第7期页码：693-699
- Affiliations：
  
  a.Key Laboratory of Rubber-Plastics, Ministry of Education/Shandong Provincial Key Laboratory of Rubber-plastics, Qingdao University of Science & Technology, Qingdao 266042, China
  b.College of Chemical Engineering and Pharmaceutics, Key Laboratory of Polymer Science and Nanotechonology, Henan University of Science and Technology, Luoyang 471003, China
- Author bio：
  
  skyan@qust.edu.cn
- Funds：
- DOI：10.1007/s10118-019-2226-z
  中图分类号：
- 收稿：2018-12-24，
  
  修回：2019-1-9，
  
  录用：2019-1-17，
  
  网络首发：2019-02-27，
  
  纸质出版：2019-07
- Accepted：
Scan QR Code
Citation: Hu, J.; Xin, R.; Hou, C. Y.; Yan, S. K.; Liu, J. C. Direct comparison of crystal nucleation activity of PCL on patterned substrates. Chinese J. Polym. Sci. 2019, 37, 693–699

Jian Hu, Rui Xin, Chun-Yue Hou, et al. Direct Comparison of Crystal Nucleation Activity of PCL on Patterned Substrates[J]. Chinese Journal of Polymer Science, 2019, 37(7): 693-699.
Citation: Hu, J.; Xin, R.; Hou, C. Y.; Yan, S. K.; Liu, J. C. Direct comparison of crystal nucleation activity of PCL on patterned substrates. Chinese J. Polym. Sci. 2019, 37, 693–699 DOI： 10.1007/s10118-019-2226-z.

Jian Hu, Rui Xin, Chun-Yue Hou, et al. Direct Comparison of Crystal Nucleation Activity of PCL on Patterned Substrates[J]. Chinese Journal of Polymer Science, 2019, 37(7): 693-699. DOI： 10.1007/s10118-019-2226-z.

摘要

Abstract

A sample containing different regions with poly(

-caprolactone) (PCL)

oriented polyethylene (PE)

and oriented isotactic polypropylene (

PP) films in contact with glass slide has been prepared to be observed in the same view field in an optical microscope and the crystallization of PCL in different regions during cooling from 80 °C down to room temperature at a rate of 1 °C·min

−1

was studied. The results showed that the crystallization of PCL started first at the PE surface and then at the

PP surface

while its bulk crystallization occured much later. This indicates that though both PE and

PP are active in nucleating PCL

the nucleation ability of PE is stronger than that of

PP. This was due to a better lattice matching between PCL and PE than that between PCL and

PP. Moreover

since lattice matching existed between every (

0) lattice planes of both PCL and PE but only between the (100)

PCL

and (010)

lattice planes

the uniaxial orientation feature of the used PE and

PP films resulted in the existence of much more active nucleation sites of PCL on PE than on

PP. This led to the fact that the nucleation density of PCL at PE surface was so high that the crystallization of PCL at PE surface took place in a way like the film developing process with PCL microcrystallites happened everywhere with crystallization proceeding simultaneously. On the other hand

even though

PP also enhanced the nucleation density of PCL evidently

the crystallization of PCL at

PP surface included still a nucleation and crystal growth processes similar to that of its bulk crystallization.

关键词

Keywords

references

Xu, J.; Zhang, Z.; Xu, H.; Chen, J.; Ran, R.; Li, Z . Highly enhanced crystallization kinetics of poly(L-lactic acid) by poly(ethylene glycol) grafted graphene oxide simultaneously as heterogeneous nucleation agent and chain mobility promoter . Macromolecules , 2015 . 48 4891 - 4900 . DOI: 10.1021/acs.macromol.5b00462 http://doi.org/10.1021/acs.macromol.5b00462 .

Zhong, G.; Li, Z.; Li, L.; Shen, K . Crystallization of oriented isotactic polypropylene ( i PP) in the presence of in situ poly(ethylene terephthalate) (PET) microfibrils . Polymer , 2008 . 49 4271 - 4278 . DOI: 10.1016/j.polymer.2008.07.056 http://doi.org/10.1016/j.polymer.2008.07.056 .

Chen, L.; Zhou, W.; Su, F.; Zhang, W.; Chen, P.; Ji, Y.; Li, L . Filler-induced heterogeneous distribution of stretch-induced crystallization in natural rubber: An in-situ synchrotron-radiation micro-focused scanning X-ray diffraction study . Polymer , 2017 . 115 217 - 223 . DOI: 10.1016/j.polymer.2017.03.043 http://doi.org/10.1016/j.polymer.2017.03.043 .

Kar, G. P.; Bose, S . Nucleation barrier, growth kinetics in ternary polymer blend filled with preferentially distributed carbon nanotubes . Polymer , 2017 . 128 229 - 241 . DOI: 10.1016/j.polymer.2017.09.019 http://doi.org/10.1016/j.polymer.2017.09.019 .

Deng, H.; Xie, N.; Li, W.; Qiu, F.; Shi, A. C . Perfectly ordered patterns via corner-induced heterogeneous nucleation of self-assembling block copolymers confined in hexagonal potential wells . Macromolecules , 2015 . 48 4174 - 4182 . DOI: 10.1021/acs.macromol.5b00681 http://doi.org/10.1021/acs.macromol.5b00681 .

Flieger, A. K.; Schulz, M.; Thurn-Albrecht, T . Interface-induced crystallization of polycaprolactone on graphite via first-order prewetting of the crystalline phase . Macromolecules , 2018 . 51 189 - 194 . DOI: 10.1021/acs.macromol.7b02113 http://doi.org/10.1021/acs.macromol.7b02113 .

Chatterjee, A. M.; Price, F. P.; Newmann, S . Heterogeneous nucleation of crystallization of high polymers from the melt. I. Substrate-induced morphologies . J. Polym. Sci., Part B: Polym. Phys. , 1975 . 13 2369 - 2383 . DOI: 10.1002/pol.1975.180131211 http://doi.org/10.1002/pol.1975.180131211 .

Chatterjee, A. M.; Price, F. P.; Newmann, S . Heterogeneous nucleation of crystallization of high polymers from the melt. II. Aspects of transcrystallinity and nucleation density . J. Polym. Sci., Part B: Polym. Phys. , 1975 . 13 2385 - 2390 . DOI: 10.1002/pol.1975.180131212 http://doi.org/10.1002/pol.1975.180131212 .

Chatterjee, A. M.; Price, F. P.; Newmann, S . Heterogeneous nucleation of crystallization of high polymers from the melt. III. Nucleation kinetics and interfacial energies . J. Polym. Sci., Part B: Polym. Phys. , 1975 . 13 2391 - 2400 . .

Fillon, B.; Lotz, B.; Thierry, A.; Wittmann, J. C . Self-nucleation and enhanced nucleation of polymers. Definition of a convenient calorimetric " efficiency scale” and evaluation of nucleating additives in isotactic polypropylene ( α phase) . J. Polym. Sci., Part B: Polym. Phys. , 1993 . 31 1395 - 1405 . DOI: 10.1002/polb.1993.090311014 http://doi.org/10.1002/polb.1993.090311014 .

Fillon, B.; Wittmann, J. C.; Lotz, B.; Thierry, A . Self-nucleation and enhanced nucleation of polymers. Definition of a convenient calorimetric "efficiency scale" and evaluation of nucleating additives in isotactic polypropylene ( α phase) . J. Polym. Sci., Part B: Polym. Phys. , 1993 . 31 1383 - 1393 . .

Petermann, J.; Gohil, R. M . A new method for the preparation of high modulus thermoplastic films . J. Mater. Sci. , 1979 . 14 2260 - 2264 . DOI: 10.1007/BF00688435 http://doi.org/10.1007/BF00688435 .

Gohil, R. M.; Miles, M. J.; Petermann, J . On the molecular mechanism of the crystal transformation (tetragonai-hexagonai) in polybutene-1 . J. Macromol. Sci.-Phys. , 1982 . B21 ( 2 ): 189 - 201 . .

Guan, G.; Zhang, J.; Sun, Li, H.; Yan, S.; Lotz, B . Oriented overgrowths of poly(L-lactide) on oriented isotactic polypropylene: A sequence of soft and hard epitaxies . Macromol. Rapid Commun. , 2018 . 39 1800353 DOI: 10.1002/marc.201800353 http://doi.org/10.1002/marc.201800353 .

Guo, Z.; Li, S.; Liu, X.; Zhang, J.; Li, H.; Sun, X.; Ren, Z.; Yan, S . Epitaxial crystallization of isotactic poly(methyl methacrylate) from different states on highly oriented polyethylene thin film . J. Phys. Chem. B , 2018 . 122 9425 - 9433 . DOI: 10.1021/acs.jpcb.8b08193 http://doi.org/10.1021/acs.jpcb.8b08193 .

Ma, L.; Zhou, Z.; Zhang, J.; Sun, X.; Li, H.; Zhang, J.; Yan, S . Temperature-dependent recrystallization morphologies of carbon-coated isotactic polypropylene highly oriented thin films . Macromolecules , 2017 . 50 3582 - 3589 . DOI: 10.1021/acs.macromol.7b00299 http://doi.org/10.1021/acs.macromol.7b00299 .

Zhang, J.; Ruan, J.; Yan, S . Epitaxy of PLLA/PCL blends on highly oriented polyethylene substrate . Acta Polymerica Sinica (in Chinese) , 2017 . 1524 - 1529 . .

Ma, L.; Zhang, J.; Memon, M. A.; Sun, X; Li, H; Yan, S . Melt recrystallization behavior of carbon coated melt-drawn oriented isotactic polypropylene thin films . Polym. Chem. , 2015 . 6 7524 - 7532 . DOI: 10.1039/C5PY01083G http://doi.org/10.1039/C5PY01083G .

Zhou, H.; Yan, S . Can the structures of semicrystalline polymers be controlled using interfacial crystallographic interactions? . Macromol. Chem. Phys. , 2013 . 214 639 - 653 . DOI: 10.1002/macp.v214.6 http://doi.org/10.1002/macp.v214.6 .

Wu, J.; Zhou, H.; Liu, Q.; Yan, S . Application of electron diffraction in the structure characterization of polymer crystals . Chinese J. Polym. Sci. , 2013 . 31 ( 6 ): 841 - 852 . DOI: 10.1007/s10118-013-1269-9 http://doi.org/10.1007/s10118-013-1269-9 .

Yan, C.; Guo, L.; Chang, H.; Yan, S . Induced crystallization of poly(ethylene adipate) by highly oriented polyethylene . Chinese J. Polym. Sci. , 2013 . 31 ( 8 ): 1173 - 1182 . DOI: 10.1007/s10118-013-1292-x http://doi.org/10.1007/s10118-013-1292-x .

Li, H.; Yan, S . Surface-induced polymer crystallization and the resultant structures and morphologies . Macromolecules , 2011 . 44 417 - 428 . DOI: 10.1021/ma1023457 http://doi.org/10.1021/ma1023457 .

An, Y.; Jiang, S.; Yan, S.; Sun J. R.; Chen, X . Crystallization behavior of polylactide on highly oriented polyethylene thin films . Chinese J. Polym. Sci. , 2011 . 29 513 - 519 . DOI: 10.1007/s10118-010-1028-0 http://doi.org/10.1007/s10118-010-1028-0 .

Chang, H.; Guo, Q.; Shen, D.; Li, L.; Qiu, Z.; Wang, F.; Yan, S . A study on the oriented recrystallization of carbon-coated pre-oriented ultrathin polyethylene films . J. Phys. Chem. B , 2010 . 114 13104 - 13109 . .

Yan, S . Origin of oriented recrystallization of carbon coated pre-oriented ultra-thin polymer films . Macromolecules , 2003 . 36 339 - 345 . DOI: 10.1021/ma021387o http://doi.org/10.1021/ma021387o .

Yan, S.; Petermann, J.; Yang, D . Effects of lamellar thicknesses on the epitaxial crystallization of HDPE on the i PP substrate films . Polym. Bull. , 1997 . 38 87 - 94 . .

Yang, D. C.; Thomas, E. L . An electron microscopy and X-ray diffraction study of the microstructures of melt-drawn polyethylene films . J. Mater. Sci. , 1984 . 19 2098 - 2110 . DOI: 10.1007/BF01058086 http://doi.org/10.1007/BF01058086 .

Bu, X.; Li, H.; Yan, S . The propagation of crystal orientation in poly( ε -caprolactone)/poly(vinyl chloride) blend film after removal of induction layer . Colloid Polym. Sci. , 2017 . 295 1635 - 1642 . DOI: 10.1007/s00396-017-4127-4 http://doi.org/10.1007/s00396-017-4127-4 .

Tao, X.; Yan, S.; Yang D . Epitaxial crystallization of poly( ε -caprolactone) on highly oriented isotactic polypropylene . Chinese Chem. Lett. , 1993 . 4 1093 - 1096 . .

Liu, J.; Li, H.; Yan, S.; Xiao, Q.; Petermann, J . Epitaxial- and trans-crystallization of PCL on the highly oriented PE substrates . Colloid Polym. Sci. , 2003 . 281 601 - 607 . DOI: 10.1007/s00396-002-0810-0 http://doi.org/10.1007/s00396-002-0810-0 .

Chang, H.; Zhang, J.; Li, L.; Wang, Z.; Yang, C.; Takahashi, I.; Ozaki, Y.; Yan, S . A study on the epitaxial ordering process of the polycarprolactone on the highly oriented polyethylene substrate . Macromolecules , 2010 . 43 362 - 366 . DOI: 10.1021/ma902235f http://doi.org/10.1021/ma902235f .

Yan, C.; Li, H.; Zhang, J.; Ozaki, Y.; Shen, D.; Yan, D.; Shi, A. C.; Yan, S . Surface induced anisotropic chain ordering of polycarprolactone on oriented polyethylene substrate: Epitaxy and soft epitaxy . Macromolecules , 2006 . 39 8041 - 8048 . DOI: 10.1021/ma061188v http://doi.org/10.1021/ma061188v .

Wittmann, J. C.; Lotz, B . Epitaxial crystallization of aliphatic polyesters on trioxane and various aromatic hydrocarbons . J. Polym. Sci., Part B: Polym. Phys. , 1981 . 19 1853 - 1864 . DOI: 10.1002/pol.1981.180191205 http://doi.org/10.1002/pol.1981.180191205 .

Wittmann, J. C.; Lotz, B . Epitaxial crystallization of polyethylene on organic substrates: A reappraisal of the mode of action of selected nucleating agents . J. Polym. Sci., Part B: Polym. Phys. , 1981 . 19 1837 - 1851 . DOI: 10.1002/pol.1981.180191204 http://doi.org/10.1002/pol.1981.180191204 .

Wittmann, J. C.; Lotz, B . Epitaxial crystallization of polymers on organic and polymeric substrate . Prog. Polym. Sci. , 1990 . 15 909 - 948 . DOI: 10.1016/0079-6700(90)90025-V http://doi.org/10.1016/0079-6700(90)90025-V .

Hu, H.; Dorset, D. L . Crystal structure of poly( ε -caprolactone) . Macromolecules , 1990 . 23 4604 - 4607 . DOI: 10.1021/ma00223a017 http://doi.org/10.1021/ma00223a017 .

Bittiger, H.; Marchessault, R. H.; Niegisch, W. O . Crystal structure of poly- ε -caprolactone . Acta Cryst. , 1970 . B26 1923 - 1927 . .

Chatani, Y.; Okita, Y.; Tadokoro, H.; Yamashita, Y . Structural studies of polyesters. III. Crystal structure of poly- ε -caprolactone . Polym. J. , 1970 . 1 555 - 562 . DOI: 10.1295/polymj.1.555 http://doi.org/10.1295/polymj.1.555 .

Núñeza, E.; Ferrandoa, C.; Malmströma, E.; Claessona, H.; Wernerb, P. E.; Gedde, U. W . Crystal structure, melting behaviour and equilibrium melting point of star polyesters with crystallisable poly( ε -caprolactone) arms . Polymer , 2004 . 45 5251 - 5263 . DOI: 10.1016/j.polymer.2004.05.047 http://doi.org/10.1016/j.polymer.2004.05.047 .

Bunn, C. W . The crystal structure of long-chain normal paraffin hydrocarbons. The " shape” of the > CH 2 group . Trans. Faraday Soc. , 1939 . 35 482 - 491 . DOI: 10.1039/TF9393500482 http://doi.org/10.1039/TF9393500482 .

浏览量

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

Influence of Freezing Layer on the Crystallization Kinetics of PCL on Oriented PE Film

Block Copolymer Networks Composed of Poly(ε-caprolactone) and Polyethylene with Triple Shape Memory Properties

INDUCED CRYSTALLIZATION BEHAVIOR OF POLY(ETHYLENE ADIPATE) BY HIGHLY ORIENTED POLYETHYLENE

Upgrading Commercially Available Polyethylene to High-value Materials with Strong Mechanical Performance and Hydrophilicity by Blending with Ethylene/meta-Methoxystyrene Copolymers

Modulating Molecular Weight of Polyethylenes from Oligomer to Polymer Using Highly Thermal Stable Cationic α-Diimine Palladium Complexes