Dewetting Behavior of Hydrogen Bonded Polymer Complex Film under Hydrothermal Condition

Chao Su; Song-Mei Ma; Geng-Xin Liu; Shu-Guang Yang

doi:10.1007/s10118-018-2109-8

Your Location：

Home >

Browse articles >

Dewetting Behavior of Hydrogen Bonded Polymer Complex Film under Hydrothermal Condition

ARTICLE | Updated：2021-02-18

- Dewetting Behavior of Hydrogen Bonded Polymer Complex Film under Hydrothermal Condition
- Dewetting Behavior of Hydrogen Bonded Polymer Complex Film under Hydrothermal Condition
- Chinese Journal of Polymer Science 2018年36卷第9期页码：1036-1042
- Affiliations：
  
  a.State Key Laboratory for Modification of Chemical Fibers and Polymer Materials, Center for Advanced Low-dimension Materials, College of Material Science and Engineering, Donghua University, Shanghai 201620, China
  b.Department of Polymer Science, The University of Akron, OH 44325, USA
- Author bio：
  
  shgyang@dhu.edu.cn
- Funds：
  
  This work was financially supported by the National Natural Science Foundation of China (No. 51373032).
- DOI：10.1007/s10118-018-2109-8
  中图分类号：
- 收稿：2017-12-13，
  
  修回：2018-1-4，
  
  录用：2018-1-10，
  
  网络首发：2018-03-15，
  
  纸质出版：2018-09
- Accepted：
Scan QR Code
Chao Su, Song-Mei Ma, Geng-Xin Liu, 等. Dewetting Behavior of Hydrogen Bonded Polymer Complex Film under Hydrothermal Condition[J]. Chinese Journal of Polymer Science, 2018,36(9):1036-1042.

Chao Su, Song-Mei Ma, Geng-Xin Liu, et al. Dewetting Behavior of Hydrogen Bonded Polymer Complex Film under Hydrothermal Condition[J]. Chinese Journal of Polymer Science, 2018, 36(9): 1036-1042.
Chao Su, Song-Mei Ma, Geng-Xin Liu, 等. Dewetting Behavior of Hydrogen Bonded Polymer Complex Film under Hydrothermal Condition[J]. Chinese Journal of Polymer Science, 2018,36(9):1036-1042. DOI： 10.1007/s10118-018-2109-8.

Chao Su, Song-Mei Ma, Geng-Xin Liu, et al. Dewetting Behavior of Hydrogen Bonded Polymer Complex Film under Hydrothermal Condition[J]. Chinese Journal of Polymer Science, 2018, 36(9): 1036-1042. DOI： 10.1007/s10118-018-2109-8.

摘要

Abstract

Hydrogen-bonded polymer complex films with the thickness ranging from 50 nm to 2400 nm were prepared by layer-by-layer (LbL) assembly of poly(2-ethyl-2-oxazoline) (PEOX) and poly(acrylic acid) (PAA). The dewetting behavior of PEOX/PAA films under hydrothermal condition was investigated. It was found that the dewetting occurred at solid-liquid interface

and the typical morphologies such as holes

irregular cellular structure

and droplets were observed. Atomic force microscopy (AFM) revealed the initial rupture of the film. Microscopic Raman and infrared (IR) imaging demonstrated that the PEOX and PAA chains remained association during the dewetting process.

关键词

Keywords

references

Thiele, U . Open questions and promising new fields in dewetting . Eur. Phys. J. E , 2003 . 12 ( 3 ): 409 - 416 . DOI: 10.1140/epje/e2004-00009-4 http://doi.org/10.1140/epje/e2004-00009-4 .

Herminghaus, S.; Brinkmann, M.; Seemann, R . Wetting and dewetting of complex surface geometries . Annu. Rev. Mater. Res. , 2008 . 38 ( 1 ): 101 - 121 . DOI: 10.1146/annurev.matsci.38.060407.130335 http://doi.org/10.1146/annurev.matsci.38.060407.130335 .

Xue, L.; Han, Y . Pattern formation by dewetting of polymer thin film . Prog. Polym. Sci. , 2011 . 36 ( 2 ): 269 - 293 . DOI: 10.1016/j.progpolymsci.2010.07.004 http://doi.org/10.1016/j.progpolymsci.2010.07.004 .

Meredith, J. C.; Smith, A. P.; Karim, A.; Amis, E. J . Combinatorial materials science for polymer thin-film dewetting . Macromolecules , 2000 . 33 ( 26 ): 9747 - 9756 . DOI: 10.1021/ma001298g http://doi.org/10.1021/ma001298g .

Koplik, J . Molecular simulations of dewetting . Phys. Rev. Lett. , 2000 . 84 ( 19 ): 4401 - 4404 . DOI: 10.1103/PhysRevLett.84.4401 http://doi.org/10.1103/PhysRevLett.84.4401 .

Higgins, A. M.; Jones, R. A. L . Anisotropic spinodal dewetting as a route to self-assembly of patterned surfaces . Nature , 2000 . 404 ( 6777 ): 476 - 478 . DOI: 10.1038/35006597 http://doi.org/10.1038/35006597 .

Wang, J. Z.; Zheng, Z. H.; Li, H. W.; Huck, W. T. S.; Sirringhaus, H . Dewetting of conducting polymer inkjet droplets on patterned surfaces . Nat. Mater. , 2004 . 3 ( 3 ): 171 - 176 . DOI: 10.1038/nmat1073 http://doi.org/10.1038/nmat1073 .

Powell, M. R.; Cleary, L.; Davenport, M.; Shea, K. J.; Siwy, Z. S . Electric-field-induced wetting and dewetting in single hydrophobic nanopores . Nat. Nanotech. , 2011 . 6 ( 12 ): 798 - 802 . DOI: 10.1038/nnano.2011.189 http://doi.org/10.1038/nnano.2011.189 .

Seemann, R.; Herminghaus, S.; Jacobs, K . Gaining control of pattern formation of dewetting liquid films . J. Phys. Condens. Matter , 2001 . 13 ( 13 ): 4925 - 4938 . .

van Hameren, R.; Schön, P.; van Buul, A. M.; Hoogboom, J.; Lazarenko, S. V.; Gerritsen, J. W.; Engelkamp, H.; Christianen, P. C. M.; Heus, H. A.; Maan, J. C.; Rasing, T.; Speller, S.; Rowan, A. E.; Elemans, J. A. A. W.; Nolte, R. J. M . Macroscopic hierarchical surface patterning of porphyrin trimers via self-assembly and dewetting . Science , 2006 . 314 ( 5804 ): 1433 - 1436 . DOI: 10.1126/science.1133004 http://doi.org/10.1126/science.1133004 .

Liu, J. C.; Shang, Y. Y.; Zhang, D. J.; Xie, Z.; Hua, R. X.; Wang, J. J . Single-material solvent-sensitive fluorescent actuator from carbon dots inverse opals based on gradient dewetting . Chinese J. Polym. Sci. , 2017 . 35 ( 9 ): 1043 - 1050 . DOI: 10.1007/s10118-017-1981-y http://doi.org/10.1007/s10118-017-1981-y .

Wang, W. C.; Shi, K.; Pan, Y. X.; Peng, C.; Zhao, Z. L.; Liu, W.; Liu, Y. G.; Ji, X. L . Fabrication of polymersomes with controllable morphologies through dewetting W/O/W double emulsion droplets . Chinese J. Polym. Sci. , 2016 . 34 ( 4 ): 475 - 482 . DOI: 10.1007/s10118-016-1769-5 http://doi.org/10.1007/s10118-016-1769-5 .

Brochard-Wyart, F. " Droplet: capillarity and wetting”. Soft Matter Phys., Spinger-Verlag Berlin Heidelberg, 1999, p. 29

Vrij, A . Possible mechanism for the spontaneous rupture of thin, free liquid films . Discuss. Faraday Soc. , 1966 . 42 23 - 33 . DOI: 10.1039/df9664200023 http://doi.org/10.1039/df9664200023 .

Redon, C.; Brochardwyart, F.; Rondelez, F . Dynamics of dewetting . Phys. Rev. Lett. , 1991 . 66 ( 66 ): 715 - 718 . .

Reiter, G . Dewetting of thin polymer-films . Phys. Rev. Lett. , 1992 . 68 ( 1 ): 75 - 78 . DOI: 10.1103/PhysRevLett.68.75 http://doi.org/10.1103/PhysRevLett.68.75 .

Reiter, G . Dewetting as a probe of polymer mobility in thin films . Macromolecules , 1994 . 27 ( 11 ): 3046 - 3052 . DOI: 10.1021/ma00089a023 http://doi.org/10.1021/ma00089a023 .

Mukherjee, R.; Sharma, A . Instability, self-organization and pattern formation in thin soft films . Soft Matter , 2015 . 11 ( 45 ): 8717 - 8740 . DOI: 10.1039/C5SM01724F http://doi.org/10.1039/C5SM01724F .

Mitlin, V. S . Dewetting of solid surface: analogy with spinodal decomposition . J. Colloid Interface Sci. , 1993 . 156 ( 2 ): 491 - 497 . DOI: 10.1006/jcis.1993.1142 http://doi.org/10.1006/jcis.1993.1142 .

Redon, C.; Brzoska, J. B.; Brochardwyart, F . Dewetting and slippage of microscopic polymer films . Macromolecules , 1994 . 27 ( 2 ): 468 - 471 . DOI: 10.1021/ma00080a021 http://doi.org/10.1021/ma00080a021 .

Xie, R.; Karim, A.; Douglas, J. F.; Han, C. C.; Weiss, R. A . Spinodal dewetting of thin polymer films . Phys. Rev. Lett. , 1998 . 81 ( 6 ): 1251 - 1254 . DOI: 10.1103/PhysRevLett.81.1251 http://doi.org/10.1103/PhysRevLett.81.1251 .

Roy, S.; Mukherjee, R . Ordered to isotropic morphology transition in pattern-directed dewetting of polymer thin films on substrates with different feature heights . ACS Appl. Mater. Interfaces , 2012 . 4 ( 10 ): 5375 - 5385 . DOI: 10.1021/am301311d http://doi.org/10.1021/am301311d .

Seemann, R.; Herminghaus, S.; Jacobs, K . Dewetting patterns and molecular forces: areconciliation . Phys. Rev. Lett. , 2001 . 86 ( 24 ): 5534 - 5537 . DOI: 10.1103/PhysRevLett.86.5534 http://doi.org/10.1103/PhysRevLett.86.5534 .

Bhandaru, N.; Das, A.; Salunke, N.; Mukherjee, R . Ordered alternating binary polymer nanodroplet array by sequential spin dewetting . Nano Lett. , 2014 . 14 ( 12 ): 7009 - 7016 . DOI: 10.1021/nl5033205 http://doi.org/10.1021/nl5033205 .

Bhandaru, N.; Goohpattader, P. S.; Faruqui, D.; Mukherjee, R.; Sharma, A . Solvent-vapor-assisted dewetting of prepatterned thin polymer films: control of morphology, order, and pattern miniaturization . Langmuir , 2015 . 31 ( 10 ): 3203 - 3214 . DOI: 10.1021/la5045738 http://doi.org/10.1021/la5045738 .

Bhandaru, N.; Das, A.; Mukherjee, R . Confinement induced ordering in dewetting of ultra-thin polymer bilayers on nanopatterned substrates . Nanoscale , 2016 . 8 ( 2 ): 1073 - 1087 . DOI: 10.1039/C5NR06690E http://doi.org/10.1039/C5NR06690E .

Chen, D.; Zhao, W.; Wei, D.; Russell, T. P . Dewetting on curved interfaces: a simple route to polymer nanostructures . Macromolecules , 2011 . 44 ( 20 ): 8020 - 8027 . DOI: 10.1021/ma2015276 http://doi.org/10.1021/ma2015276 .

Xia, T.; Ogawa, H.; Inoue, R.; Nishida, K.; Yamada, N. L.; Li, G.; Kanaya, T . Dewetting process of deuterated polystyrene and poly(vinyl methylether) blend thin films via phase separation . Macromolecules , 2013 . 46 ( 11 ): 4540 - 4547 . DOI: 10.1021/ma400506f http://doi.org/10.1021/ma400506f .

Li, S. J.; Zhang, W. X.; Jiang, F.; Lu, Y. Y.; Shi, T. F.; An, L. J . Dynamics of hole growing in polymer thin films during dewetting . Acta Polymerica Sinica (in Chinese) , 2014 . 24 ( 9 ): 1174 - 1181 . .

Che, J.; Jawaid, A.; Grabowski, C. A.; Yi, Y.; Louis, G. C.; Ramakrishnan, S.; Vaia, R. A . Stability of polymer grafted nanoparticle monolayers: impact of architecture and polymer-substrate interactions on dewetting . ACS Macro Lett. , 2016 . 5 ( 12 ): 1369 - 1374 . DOI: 10.1021/acsmacrolett.6b00772 http://doi.org/10.1021/acsmacrolett.6b00772 .

Chandran, S.; Reiter, G . Transient cooperative processes in dewetting polymer melts . Phys. Rev. Lett. , 2016 . 116 ( 8 ): 088301 DOI: 10.1103/PhysRevLett.116.088301 http://doi.org/10.1103/PhysRevLett.116.088301 .

Liu, P.; Huang, X.; Zhou, R.; Berne, B. J . Observation of a dewetting transition in the collapse of the melittin tetramer . Nature , 2005 . 437 ( 7055 ): 159 - 162 . DOI: 10.1038/nature03926 http://doi.org/10.1038/nature03926 .

Farrell, R. A.; Kehagias, N.; Shaw, M. T.; Reboud, V.; Zelsmann, M.; Holmes, J. D.; Torres, C. M. S.; Morris, M. A . Surface-directed dewetting of a block copolymer for fabricating highly uniform nanostructured microdroplets and concentric nanorings . ACS Nano , 2011 . 5 ( 2 ): 1073 - 1085 . DOI: 10.1021/nn102720m http://doi.org/10.1021/nn102720m .

Besancon, B. M.; Green, P. F . Dewetting dynamics in miscible polymer-polymer thin film mixtures . J. Chem. Phys. , 2007 . 126 ( 22 ): 224903 DOI: 10.1063/1.2737043 http://doi.org/10.1063/1.2737043 .

Ma, M.; He, Z.; Yang, J.; Wang, Q.; Chen, F.; Wang, K.; Zhang, Q.; Deng, H.; Fu, Q . Vertical phase separation and liquid-liquid dewetting of thin PS/PCL blend films during spin coating . Langmuir , 2011 . 27 ( 3 ): 1056 - 1063 . DOI: 10.1021/la104003p http://doi.org/10.1021/la104003p .

Merola, F.; Grilli, S.; Coppola, S.; Vespini, V.; Nicola, S. D.; Maddalena, P.; Carfagna, C.; Ferraro, P . Reversible fragmentation and self-assembling of nematic liquid crystal droplets on functionalized pyroelectric substrates . Adv. Funct. Mater. , 2012 . 22 ( 15 ): 3097 - 3097 . DOI: 10.1002/adfm.v22.15 http://doi.org/10.1002/adfm.v22.15 .

Fowlkes, J. D.; Kondic, L.; Diez, J.; Wu, Y.; Rack, P. D . Self-assembly versus directed assembly of nanoparticles via pulsed laser induced dewetting of patterned metal films . Nano Lett. , 2011 . 11 ( 6 ): 2478 - 2485 . DOI: 10.1021/nl200921c http://doi.org/10.1021/nl200921c .

Krishna, H.; Sachan, R.; Strader, J.; Favazza, C.; Khenner, M.; Kalyanaraman, R . Thickness-dependent spontaneous dewetting morphology of ultrathin Ag films . Nanotechnolgy , 2010 . 21 ( 15 ): 155601 DOI: 10.1088/0957-4484/21/15/155601 http://doi.org/10.1088/0957-4484/21/15/155601 .

Péron, N.; Brochard-Wyart, F.; Duval, H . Dewetting of low-viscosity films at solid/liquid interfaces . Langmuir , 2012 . 28 ( 45 ): 15844 - 15852 . DOI: 10.1021/la303374m http://doi.org/10.1021/la303374m .

Verma, A.; Sharma, A . Enhanced self-organized dewetting of ultrathin polymer films under water-organic solutions: fabrication of sub-micrometer spherical lens arrays . Adv. Mater. , 2010 . 22 ( 46 ): 5306 - 5309 . DOI: 10.1002/adma.201002768 http://doi.org/10.1002/adma.201002768 .

Verma, A.; Sharma, A . Submicrometer pattern fabrication by intensification of instability in ultrathin polymer films under a water-solvent mix . Macromolecules , 2011 . 44 ( 12 ): 4928 - 4935 . DOI: 10.1021/ma200113w http://doi.org/10.1021/ma200113w .

Decher, G . Fuzzy nanoassemblies: toward layered polymeric multicomposites . Science , 1997 . 277 ( 5330 ): 1232 - 1237 . DOI: 10.1126/science.277.5330.1232 http://doi.org/10.1126/science.277.5330.1232 .

Borges, J.; Mano, J. F . Molecular interactions driving the layer-by-layer assembly of multilayers . Chem. Rev. , 2014 . 114 ( 18 ): 8883 - 8942 . DOI: 10.1021/cr400531v http://doi.org/10.1021/cr400531v .

Richardson, J. J.; Bjornmalm, M.; Caruso, F . Technology-driven layer-by-layer assembly of nanofilms . Science , 2015 . 348 ( 6233 ): aaa2491 DOI: 10.1126/science.aaa2491 http://doi.org/10.1126/science.aaa2491 .

Zhang, L.; Zheng, M.; Liu, X.; Sun, J . Layer-by-layer assembly of salt-containing polyelectrolyte complexes for the fabrication of dewetting-induced porous coatings . Langmuir , 2011 . 27 ( 4 ): 1346 - 1352 . DOI: 10.1021/la103953n http://doi.org/10.1021/la103953n .

Shim, B. S.; Podsiadlo, P.; Lilly, D.G.; Agarwal, A.; Lee, J.; Tang, Z.; Ho, S.; Ingle, P.; Paterson, D.; Lu, W.; Kotov, N. A . Nanostructured thin films made by dewetting method of layer-by-layer assembly . Nano Lett. , 2007 . 7 ( 11 ): 3266 - 3273 . DOI: 10.1021/nl071245d http://doi.org/10.1021/nl071245d .

Cao, Y . Fluorescence staining and confocal laser scanning microscopy study of hydrogen-bonded poly(vinylpyrrolidone)/poly(acrylic acid) film . Colloids Surf. A , 2011 . 392 ( 1 ): 83 - 87 . DOI: 10.1016/j.colsurfa.2011.09.037 http://doi.org/10.1016/j.colsurfa.2011.09.037 .

Yang, S.; Li, Y.; Li, X.; Li, Y.; Zhang, X.; Xu, J . Patterning of hydrogen-bonded assembly film through ionization in vapor . Thin Solid Films , 2009 . 517 ( 9 ): 3024 - 3027 . DOI: 10.1016/j.tsf.2008.12.001 http://doi.org/10.1016/j.tsf.2008.12.001 .

Ma, S.; Qi, X.; Cao, Y.; Yang, S.; Xu, J . Hydrogen bond detachment in polymer complexes . Polymer , 2013 . 54 ( 20 ): 5382 - 5390 . DOI: 10.1016/j.polymer.2013.07.047 http://doi.org/10.1016/j.polymer.2013.07.047 .

Decher, G.; Hong, J. D . Buildup of ultrathin multilayer films by a self-assembly process (1), consecutive adsorption of anionic and cationic bipolar amphiphiles on charged surfaces . Macromol. Symposia , 1991 . 46 ( 11 ): 321 - 327 . .

Stockton, W. B.; Rubner, M. F . Molecular-level processing of conjugated polymers . 4. layer-by-layer manipulation of polyaniline via hydrogen-bonding interactions. Macromolecules , 1997 . 30 ( 9 ): 2717 - 2725 . .

Wang, L.; Wang, Z.; Zhang, X.; Shen, J.; Chi, L.; Fuchs, H . A new approach for the fabrication of an alternating multilayer film of poly(4-vinylpyridine) and poly(acrylic acid) based on hydrogen bonding . Macromol. Rapid Commun. , 1997 . 18 ( 6 ): 509 - 514 . DOI: 10.1002/marc.1997.030180609 http://doi.org/10.1002/marc.1997.030180609 .

Kharlampieva, E.; Sukhishvili, S. A . Hydrogen-bonded layer-by-layer polymer films . Polym. Rev. , 2006 . 46 ( 4 ): 377 - 395 . .

Yang, S.; Ma, S.; Wang, C.; Xu, J.; Zhu, M . Polymer complexation by hydrogen bonding at the interface . Aust. J. Chem. , 2014 . 67 ( 1 ): 11 - 21 . DOI: 10.1071/CH13485 http://doi.org/10.1071/CH13485 .

Su, C.; Sun, J.; Zhang, X.; Shen, D.; Yang, S . Hydrogen-bonded polymer complex thin film of poly(2-oxazoline) and poly(acrylic acid) . Polymers , 2017 . 9 ( 8 ): 363 DOI: 10.3390/polym9080363 http://doi.org/10.3390/polym9080363 .

Yang, S.; Tan, S.; Zhang, Y.; Xu, J.; Zhang, X . Interferometric study onhydrogen-bonded assembly film . Thin Solid Films , 2008 . 516 4018 - 4024 . DOI: 10.1016/j.tsf.2007.08.010 http://doi.org/10.1016/j.tsf.2007.08.010 .

Ma, J.; Yang, S.; Li, Y.; Xu, X.; Xu, J . Effect of temperature on build-up and post hydrothermal processing of hydrogen-bonded PVPON/PAA film . Soft Matter , 2011 . 7 ( 19 ): 9435 - 9443 . DOI: 10.1039/c1sm05587a http://doi.org/10.1039/c1sm05587a .

Wang, Z.; Xu, J.; Wu, L.; Chen, X.; Yang, S.; Liu, H.; Zhou, X . Dissolution, hydrolysis and crystallization behavior of polyamide 6 in superheated water . Chinese J. Polym. Sci. , 2015 . 33 ( 9 ): 1334 - 1343 . DOI: 10.1007/s10118-015-1682-3 http://doi.org/10.1007/s10118-015-1682-3 .

Zhang, Y.; Li, F.; Valenzuela, L. D.; Sammalkorpi, M.; Lutkenhaus, J. L . Effect of water on the thermal transition observed in poly(allylamine hydrochloride)-poly(acrylic acid) complexes . Macromolecules , 2016 . 49 ( 19 ): 7563 - 7570 . DOI: 10.1021/acs.macromol.6b00742 http://doi.org/10.1021/acs.macromol.6b00742 .

Zhai, L.; Nolte, A. J.; Cohen, R. E.; Rubner, M. F . pH-gated porosity transitions of polyelectrolyte multilayers in confined geometries and their application as tunable bragg reflectors . Macromolecules , 2004 . 37 ( 16 ): 6113 - 6123 . DOI: 10.1021/ma049593e http://doi.org/10.1021/ma049593e .

Yang, S.; Zhang, Y.; Guan, Y.; Tan, S.; Zhang, X.; Cheng, S.; Xu, J . Water uptake behavior of hydrogen-bonded PVPON/PAA LbL film . Soft Matter , 2006 . 2 ( 8 ): 699 - 704 . DOI: 10.1039/B606923A http://doi.org/10.1039/B606923A .

浏览量

247

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

Effect of Interfacial Adsorption on the Stability of Thin Polymer Films in a Solvent-induced Process

Phase Separation, Wetting and Dewetting in PS/PVME Blend Thin Films: Dependence on Film Thickness and Composition Ratio

Slow Down Dewetting in Polymer Films by Isocyanate-treated Graphite Oxide

Dewetting Kinetics of Thin Polymer Films with Different Architectures: Effect of Polymer Adsorption

The Effect of Polymer-Substrate Interaction on the Nucleation Property: Comparing Study of Graphene and Hexagonal Boron Nitride Nanosheets