Infectious Behavior in Photo-oxidation of Polymers

Xuan Liu; Xiao-Peng Ren; Rui Yang

doi:10.1007/s10118-020-2344-7

Your Location：

Home >

Browse articles >

Infectious Behavior in Photo-oxidation of Polymers

ARTICLE | Updated：2019-10-12

- Infectious Behavior in Photo-oxidation of Polymers
- Chinese Journal of Polymer Science Vol. 38, Issue 3, Pages: 248-256(2020)
- Affiliations：
  
  Department of Chemical Engineering, Tsinghua University, Beijing 100084, China
- Author bio：
  
  yangr@mail.tsinghua.edu.cn
- Funds：
- DOI：10.1007/s10118-020-2344-7
  CLC：
- Received：30 June 2019，
  
  Revised：2019-8-13，
  
  Accepted：23 August 2019，
  
  Online First：12 October 2019，
  
  Published：2020-03
- Accepted：
Scan QR Code
Citation: Liu, X.; Ren, X. P.; Yang, R. Infectious behavior in photo-oxidation of polymers. Chinese J. Polym. Sci. 2020, 38, 248–256

Xuan Liu, Xiao-Peng Ren, Rui Yang. Infectious Behavior in Photo-oxidation of Polymers[J]. Chinese Journal of Polymer Science, 2020, 38(3): 248-256.
Citation: Liu, X.; Ren, X. P.; Yang, R. Infectious behavior in photo-oxidation of polymers. Chinese J. Polym. Sci. 2020, 38, 248–256 DOI： 10.1007/s10118-020-2344-7.

Xuan Liu, Xiao-Peng Ren, Rui Yang. Infectious Behavior in Photo-oxidation of Polymers[J]. Chinese Journal of Polymer Science, 2020, 38(3): 248-256. DOI： 10.1007/s10118-020-2344-7.

摘要

Abstract

When a polymer is used together with others

its aging process will be affected by the adjacent polymers. This infectious behavior between polymers makes the aging process more complex than that of an individual material. In this study

infectious behavior in photo-oxidation of polymers was investigated. Polypropylenes (PPs)

an unstabilized PP and a commercial PP

were chosen as the infection sources. Six typical polymers

high density polyethylene (HDPE)

low density polyethylene (LDPE)

polystyrene (PS)

polycarbonate (PC)

poly(ethylene terephthalate) (PET)

and polyamide 6 (PA6)

were used as the targets. The degree of oxidation of the targets was evaluated by attenuated total reflection-Fourier transform infrared spectroscopy (ATR-FTIR). An accelerating effect of two infection sources on the photo-oxidation of the target polymers was observed. Potential infectious agents from the infection sources were detected by pyrolysis-gas chromatography-mass spectrometry (Py-GC-MS) and gas chromatography (GC). The acceleration effect of two main infectious agents

. acetone and acetic acid

on the photo-oxidation of the commercial PP was verified. The infectious effect of the infection source on the target polymer was considered to be a comprehensive result of the effects of a variety of infectious agents.

关键词

Keywords

references

Ding, X. L.; Wang, S.; Shan, Z. H . Automotive interior decoration materials . Leather Science and Engineering (in Chinese) , 2017 . 27 36 - 39 . .

Zheng, H.; Wang, C.; Jiang, F . Development trend of the elastomers used in inner tube and innerliners . China Elastomerics (in Chinese) , 2011 . 21 98 - 103 . .

Ma, J. H.; Zhang, L. Q.; Wu, Y. P . Properties of tire tread composite and their mechanism . Polym. Bull. , 2014 . 1 - 9 . .

Moreno, D. D. P.; Saron, C . Influence of compatibilizer on the properties of low-density polyethylene/polyamide 6 blends obtained by mechanical recycling of multilayer film waste . Waste Manage. Res. , 2018 . 36 729 - 736 . DOI: 10.1177/0734242X18777795 http://doi.org/10.1177/0734242X18777795 .

Drake, W. O . The influence of sampleholders on oven aging of polypropylene . J. Polym. Sci.: Polym. Symposium , 1976 . 57 153 - 159 . .

Colwell, J. M.; Nikolic, M. A. L.; Bottle, S. E.; George, G. A . Sensitive luminescence techniques to study the early stages of polymer oxidation . Polym. Degrad. Stab. , 2013 . 98 2436 - 2444 . DOI: 10.1016/j.polymdegradstab.2013.06.010 http://doi.org/10.1016/j.polymdegradstab.2013.06.010 .

Curran, K.; Možir, A.; Underhill, M.; Gibson, L. T.; Fearn, T.; Strlič, M . Cross-infection effect of polymers of historic and heritage significance on the degradation of a cellulose reference test material . Polym. Degrad. Stab. , 2014 . 107 294 - 306 . DOI: 10.1016/j.polymdegradstab.2013.12.019 http://doi.org/10.1016/j.polymdegradstab.2013.12.019 .

Aratani, N.; Katada, I.; Nakayama, K.; Terano, M.; Taniike, T . Development of high-throughput chemiluminescence imaging instrument for parallel evaluation of polymer lifetime . Polym. Degrad. Stab. , 2015 . 121 340 - 347 . DOI: 10.1016/j.polymdegradstab.2015.09.025 http://doi.org/10.1016/j.polymdegradstab.2015.09.025 .

Celina, M.; George, G. A . Physical spreading of oxidation in solid polypropylene as studied by chemiluminescence . Polym. Degrad. Stab. , 1993 . 42 335 - 344 . DOI: 10.1016/0141-3910(93)90229-C http://doi.org/10.1016/0141-3910(93)90229-C .

Ahlblad, G.; Reitberger, T.; Terselius, B.; Stenberg, B . Imaging chemiluminescence technique applied to thermo-oxidation of polymers—possibilities and limitations . Angew. Makromol. Chem. , 1998 . 261/262 ( Nr. 4611 ): 1 - 7 . .

Ahlblad, G.; Reitberger, T.; Terselius, B.; Stenberg, B . Thermo-oxidative infection in populations of EPDM particles studied by imaging chemiluminescence . Polym. Degrad. Stab. , 1999 . 65 169 - 177 . DOI: 10.1016/S0141-3910(98)00177-3 http://doi.org/10.1016/S0141-3910(98)00177-3 .

Celina, M.; Clough, R.; Jones, G . Polymer degradation initiated via infectious behavior . Polymer , 2005 . 46 5161 - 5164 . DOI: 10.1016/j.polymer.2005.04.033 http://doi.org/10.1016/j.polymer.2005.04.033 .

Celina, M.; Clough, R. L.; Jones, G. D . Initiation of polymer degradation via transfer of infectious species . Polym. Degrad. Stab. , 2006 . 91 1036 - 1044 . DOI: 10.1016/j.polymdegradstab.2005.07.022 http://doi.org/10.1016/j.polymdegradstab.2005.07.022 .

Liu, X.; Yang, R . Cross-infection in thermo-oxidation of polymers . Polym. Degrad. Stab. , 2019 . 161 7 - 12 . DOI: 10.1016/j.polymdegradstab.2019.01.009 http://doi.org/10.1016/j.polymdegradstab.2019.01.009 .

Mistretta, M. C.; Botta, L.; Vinci, A. D.; Ceraulo, M.; La Mantia, F. P . Photo-oxidation of polypropylene/graphene nanoplatelets composites . Polym. Degrad. Stab. , 2019 . 160 35 - 43 . DOI: 10.1016/j.polymdegradstab.2018.12.003 http://doi.org/10.1016/j.polymdegradstab.2018.12.003 .

Briassoulis, D.; Hiskakis, M.; Tserotas, P . Combined effect of UVA radiation and agrochemicals on the durability of agricultural multilayer films . Polym. Degrad. Stab. , 2018 . 154 261 - 275 . DOI: 10.1016/j.polymdegradstab.2018.06.012 http://doi.org/10.1016/j.polymdegradstab.2018.06.012 .

Nayanathara, U.; Kottegoda, N.; Perera, I. C.; Mudiyanselage, T. K . Synthesis, photodegradable and antibacterial properties of polystyrene-cinnamaldehyde copolymer film . Polym. Degrad. Stab. , 2018 . 155 195 - 207 . DOI: 10.1016/j.polymdegradstab.2018.07.021 http://doi.org/10.1016/j.polymdegradstab.2018.07.021 .

Zhao, J. H.; Li, Y. F.; Yang, R.; Yu, J . Infectious behavior of polypropylene during photo-oxidation . Acta Polymerica Sinica (in Chinese) , 2015 . 369 - 373 . .

Rabello, M. S.; White, J. R . The role of physical structure and morphology in the photodegradation behaviour of polypropylene . Polym. Degrad. Stab. , 1997 . 56 55 - 73 . DOI: 10.1016/S0141-3910(96)00202-9 http://doi.org/10.1016/S0141-3910(96)00202-9 .

Guo, J. J.; Yan, H.; Bao, H. B.; Wang, X. M.; Hu, Z. D.; Yang, J. J . Attenuated total reflection infrared spectroscopy for degradation profile of high density polyethylene after weathering aging . Spectroscopy and Spectral Analysis (in Chinese) , 2015 . 35 1520 - 1524 . .

Yu, J. G.; Wang, X. D . Application of FTIR in study of thermo-oxidative degradation of PE/starch blends . Chinese Journal of Applied Chemistry (in Chinese) , 2001 . 18 48 - 51 . .

Vilaplana, F.; Ribes-Greus, A.; Karlsson, S . Degradation of recycled high-impact polystyrene simulation by reprocessing and thermo-oxidation . Polym. Degrad. Stab. , 2006 . 91 2163 - 2170 . .

Arrieta, C.; Dong, Y. Y.; Lan, A.; Vu-Khanh, T . Outdoor weathering of polyamide and polyester ropes used in fall arrest equipment . J. Appl. Polym. Sci. , 2013 . 130 3058 - 3065 . DOI: 10.1002/app.39524 http://doi.org/10.1002/app.39524 .

Guo, Y. F.; Tao, Y. J.; Ma, J.; Jie, G. X.; Zhang, X. D.; Hu, L. F.; Liu, X.; Wang, J . Study on the natural aging of polycarbonate by FTIR . Engineering plastics application (in Chinese) , 2012 . 40 77 - 80 . .

Pires, H. M.; Mendes, L. C.; Cestari, S. P.; Pita, V. J. R. R . Effect of weathering and accelerated photoaging on PET/PC (80/20 wt/wt%) melt extruded blend . Mater. Res. , 2015 . 18 763 - 768 . DOI: 10.1590/1516-1439.010115 http://doi.org/10.1590/1516-1439.010115 .

Rånby, B.; Rabek, J. F. Photodegradation, photo-oxidation and photostabilization of polymers. John Wiley & amp; Sons, London, 1975 , p. 228, 232.

Zhao, J. H.; Yang, R.; Yu, J . Interfacial effect on photo-oxidation of PP via model blends . Polym. Degrad. Stab. , 2013 . 98 1981 - 1987 . DOI: 10.1016/j.polymdegradstab.2013.07.015 http://doi.org/10.1016/j.polymdegradstab.2013.07.015 .

Fernando, S. S.; Christensen, P. A.; Egerton, T. A.; White, J. R . Carbon dioxide evolution and carbonyl group development during photodegradation of polyethylene and polypropylene . Polym. Degrad. Stab. , 2007 . 92 2163 - 2172 . DOI: 10.1016/j.polymdegradstab.2007.01.032 http://doi.org/10.1016/j.polymdegradstab.2007.01.032 .

Bendjama, H.; Merouani, S.; Hamdaoui, O.; Bouhelassa, M . Using photoactivated acetone for the degradation of Chlorazol Black in aqueous solutions: impact of mineral and organic additives . Sci. Total Environ. , 2019 . 653 833 - 838 . DOI: 10.1016/j.scitotenv.2018.11.007 http://doi.org/10.1016/j.scitotenv.2018.11.007 .

Views

Downloads

CSCD

Alert me when the article has been cited

Submit

Tools

Publicity Resources

Accelerating Role of Clay in Photo-Oxidation of Polypropylene/Clay Multifilament Yarns

Synergistic Toughening of Polypropylene Alloys Using Core-Shell High-density Polyethylene/Ethylene-Propylene Rubber and Isoprene Rubber Composite Rubber Particles

Dynamic Ionic Crosslinking Polypropylene-based Elastomers with Excellent Mechanical Properties and Antibacterial Performance

Preparation of Polypropylene Nanofibers as a Function of the Thermal Exposure Time of the Polymer in a Melt Electrospinning/Melt Blown Hybrid System

Improvements of Hydrophobicity and Toughness of Epoxy Coatings Modified with Hydroxyl-terminated Fluororubber

Related Author

S. Aslanzadeh

R. Semnani Rahbar

M. Nazi

Hai-Bo Wang

Ang-Xuan Wu

Jia-Hao Shen

Xiao-Tian Nan

Feng-Bo Zhu

Related Institution

Department of Textile and Leather, Faculty of Chemistry and Petrochemical Engineering, Standard Research Institute (SRI), Karaj,.O. Box

Department of Polymer Science and Engineering, Zhejiang University

College of Materials Science and Engineering, Taiyuan University of Technology

School of Materials Science and Engineering, Tsinghua University

Key Lab of Polymer Ecomaterials, Changchun Institute of Applied Chemistry, Chinese Academy of Sciences

⁰