Exploring Si/Mg Composite Supported Ziegler-Natta Ti-based Catalysts for Propylene Polymerization

Wei Zhu; Zhou Tian; Rui-hua Cheng; Xue-lian He; Zhen Liu; Ning Zhao; Bo-ping Liu

doi:10.1007/s10118-017-1999-1

Your Location：

Home >

Browse articles >

Exploring Si/Mg Composite Supported Ziegler-Natta Ti-based Catalysts for Propylene Polymerization

Papers | Updated：2021-02-18

- Exploring Si/Mg Composite Supported Ziegler-Natta Ti-based Catalysts for Propylene Polymerization
- Chinese Journal of Polymer Science Vol. 35, Issue 12, Pages: 1474-1487(2017)
- Affiliations：
  
  a.State Key Laboratory of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, China
  b.Key Laboratory of Advanced Control and Optimization for Chemical Processes, Ministry of Education, East China University of Science and Technology, Shanghai 200237, China
- Author bio：
  
  Zhou Tian (田洲), E-mail:tianzhou@ecust.edu.cn
  Bo-ping Liu (刘柏平), E-mail:boping@ecust.edu.cn
- Funds：
- DOI：10.1007/s10118-017-1999-1
  CLC：
- Received：22 April 2017，
  
  Revised：2017-06-22，
  
  Accepted：23 June 2017，
  
  Published：05 December 2017
- Accepted：
Scan QR Code
Wei Zhu, Zhou Tian, Rui-hua Cheng, et al. Exploring Si/Mg Composite Supported Ziegler-Natta Ti-based Catalysts for Propylene Polymerization[J]. Chinese Journal of Polymer Science, 2017, 35(12): 1474-1487.
DOI：

Wei Zhu, Zhou Tian, Rui-hua Cheng, et al. Exploring Si/Mg Composite Supported Ziegler-Natta Ti-based Catalysts for Propylene Polymerization[J]. Chinese Journal of Polymer Science, 2017, 35(12): 1474-1487. DOI： 10.1007/s10118-017-1999-1.

摘要

Abstract

A series of (SiO

/MgO/ID/MgCl

)·TiCl

Ziegler-Natta catalysts for propylene polymerization has been prepared with a new method. These catalysts were synthesized using soluble Mg-compounds as the Mg-source and the preparation progress was relatively simple. The catalyst could copy the spherical shape of the carrier very well. The propylene polymerization results showed that the catalyst revealed the best activity with 9

9-di(methoxymethyl)fluorene (BMMF) as internal donor at 50 ℃ with the optimal molar ratio Al/Ti=5

which was much lower than what the industrial polypropylene catalyst used (at least molar ratio Al/Ti=100)

resulting in great cost saving. Additionally

the polymerization kinetics of the catalyst exhibited very stable property after achieving a relatively high value. These catalysts possessed rather high activity and good hydrogen response. The isotactic index (Ⅱ) value of the PP products could be higher than 98% in the presence of both internal and external electron donors. Moreover

temperature rising elution fractionation method was used to understand the influence of donors and H

on the properties of the PP products.

关键词

Keywords

references

M. Klapper , D. Joe , S. Nietzel , J.W. Krumpfer , K. Muellen . Chem. Mater. , 2014 . 26 802 DOI: 10.1021/cm402309z http://doi.org/10.1021/cm402309z .

M. Gahleitner , L. Resconi , P. Doshev . MRS Bulletin , 2013 . 38 229 DOI: 10.1557/mrs.2013.47 http://doi.org/10.1557/mrs.2013.47 .

J.T.M. Pater , G. Weickert , W.P.M. Swaaij . Chem. Eng. Sci. , 2002 . 57 3461 DOI: 10.1016/S0009-2509(02)00213-0 http://doi.org/10.1016/S0009-2509(02)00213-0 .

K.S. Kim , Y.J. Lee , H.Y. Kim , S.S. Kang , S.Y. Kwon . Org. & Biomol. Chem. , 2004 . 2 2408 http://onlinelibrary.wiley.com/doi/10.1002/chin.200505183/full http://onlinelibrary.wiley.com/doi/10.1002/chin.200505183/full , .

Morini, G., Balbontin, G., Baruzzi, G. and Cristofori, A. B., 2006, U. S. Pat., 7, 049, 377 http://www.freepatentsonline.com/7022640.html

A. Potapov , L. Politanskaya . J. Mol. Catal. A:Chem. , 2013 . 368 159 http://www.sciencedirect.com/science/article/pii/S1381116912004025 http://www.sciencedirect.com/science/article/pii/S1381116912004025 , .

B.G. Song , S.K. Ihm . J. Appl. Polym. Sci. , 2014 . 131 http://onlinelibrary.wiley.com/doi/10.1002/app.40536/full http://onlinelibrary.wiley.com/doi/10.1002/app.40536/full , .

Morini, G., Gulevich, Y. ; Kelder, R., Duijghuisen, H. K. P. and Korndorffer, F., 2006, Eur. Pat. 1, 088, 009

S. Tanase , K. Katayama , N. Yabunouchi , T. Sadashima , N. Tomotsu , N. Ishihara . J. Mol. Catal. A:Chem. , 2007 . 273 211 DOI: 10.1016/j.molcata.2007.04.002 http://doi.org/10.1016/j.molcata.2007.04.002 .

Morini, G. and Giotto, V., 2000, WO 055, 215

D. Xu , J. Wang , Z. Liu , Y. Ke , Y. Hu . Macromol. Chem. Phys. , 2001 . 202 1817 DOI: 10.1002/(ISSN)1521-3935 http://doi.org/10.1002/(ISSN)1521-3935 .

R. Zahedi , F.A. Taromi , S.H. Mirjahanmardi , M.N. Haghighi , K. Jadidi , R. Jamjah . Chinese J. Polym. Sci. , 2016 . 34 268 DOI: 10.1007/s10118-016-1751-2 http://doi.org/10.1007/s10118-016-1751-2 .

A. Potapov , G. Bukatov , V. Zakharov . J. Mol. Catal. A:Chem. , 2009 . 301 18 DOI: 10.1016/j.molcata.2008.11.002 http://doi.org/10.1016/j.molcata.2008.11.002 .

L.L. Böhm . Angew. Chem. Int. Ed. , 2003 . 42 5010 DOI: 10.1002/(ISSN)1521-3773 http://doi.org/10.1002/(ISSN)1521-3773 .

Kimura, K. Terano, M., and Soga, H., 1988, Eur. Pat. 268, 685

Kimura, K. Terano, M., Murai, A., Inoue, M. and Miyoshi, K., 1987, JP Pat., S62, 158, 704

Udoo, H. T. Y. and Kurausuudeiitaa, K., 1994, JP Pat., 6, 087, 773

J.W. Wang , R.H. Cheng , X.L. He , Z. Liu , Z. Tian , B.P Liu . Macromol. Chem. Phys. , 2015 . 216 1472 DOI: 10.1002/macp.v216.13 http://doi.org/10.1002/macp.v216.13 .

J.W. Wang , R.H. Cheng , X.L. He , Z. Liu , B.P Liu . J. Organomet. Chem. , 2015 . 798 299 DOI: 10.1016/j.jorganchem.2015.09.012 http://doi.org/10.1016/j.jorganchem.2015.09.012 .

F. Huang , J.W. Wang , R.H. Cheng , X.L. He , Z. Liu , N. Zhao , B.P. Liu . Macromol. React. Eng. , 2016 . 10 10 .

J.W. Wang , R.H. Cheng , X.L. He , Z. Liu , B.P Liu . Macromol. React. Eng. , 2016 . 10 246 DOI: 10.1002/mren.201500056 http://doi.org/10.1002/mren.201500056 .

R.H. Cheng , J. Luo , Z. Liu , J.W. Sun , W.H. Huang , M.G. Zhang , J.J. Yi , B.P. Liu . Chinese J. Polym. Sci. , 2013 . 31 591 DOI: 10.1007/s10118-013-1252-5 http://doi.org/10.1007/s10118-013-1252-5 .

M. Terano , T. Kataoka , T. Keii . Makromol. Chem. , 1987 . 188 1477 DOI: 10.1002/macp.1987.021880622 http://doi.org/10.1002/macp.1987.021880622 .

H. Mori , K. Hasebe , M. Terano . J. Mol. Catal. A:Chem. , 1999 . 140 165 DOI: 10.1016/S1381-1169(98)00225-8 http://doi.org/10.1016/S1381-1169(98)00225-8 .

A. Correa , F. Piemontesi , G. Morini , L. Cavallo . Macromolecules , 2007 . 40 9181 DOI: 10.1021/ma071294c http://doi.org/10.1021/ma071294c .

A. Correa , R. Credendino , J.T.M. Pater , G. Morini , L. Cavallo . Macromolecules , 2012 . 45 3695 DOI: 10.1021/ma3001862 http://doi.org/10.1021/ma3001862 .

T. Taniike , M. Terano . J. Catal. , 2012 . 293 39 DOI: 10.1016/j.jcat.2012.06.001 http://doi.org/10.1016/j.jcat.2012.06.001 .

R. Credendino , D. Liguori , G. Morini , L. Cavallo . J. Phys. Chem. , 2014 . 118 8050 DOI: 10.1021/jp406540p http://doi.org/10.1021/jp406540p .

J. Hu , B. Han , X.R. Shen , Z.S. Fu , Z.Q. Fan . Chinese J. Polym. Sci. , 2013 . 31 583 DOI: 10.1007/s10118-013-1260-5 http://doi.org/10.1007/s10118-013-1260-5 .

S. Abedi , M. Daftari-Besheli , S. Shafiei . J. Appl. Polym. Sci. , 2005 . 97 1744 DOI: 10.1002/(ISSN)1097-4628 http://doi.org/10.1002/(ISSN)1097-4628 .

A. Andoni , J.C. Chadwick , H.J.W. Niemantsverdriet , P.C. Thüne . Macromol. Rapid Commun. , 2007 . 28 1437 DOI: 10.1002/(ISSN)1521-3927 http://doi.org/10.1002/(ISSN)1521-3927 .

X.R. Shen , Z.S. Fu , J. Hu , Q. Wang , Z.Q. Fan . J. Phys. Chem. C , 2013 . 117 15174 DOI: 10.1021/jp404416n http://doi.org/10.1021/jp404416n .

D.V. Stukalov , V.A. Zakharov , A.G. Potapov , G.D. Bukatov . J. Catal. , 2009 . 266 http://www.sciencedirect.com/science/article/pii/S0021951709001705 http://www.sciencedirect.com/science/article/pii/S0021951709001705 , .

B. Zhang , Q. Dong , Z.S. Fu , Z.Q. Fan . Polymer , 2014 . 55 4865 DOI: 10.1016/j.polymer.2014.08.019 http://doi.org/10.1016/j.polymer.2014.08.019 .

B. Zhang , L. Zhang , Z.S. Fu , Z.Q. Fan . Catal. Commun. , 2015 . 69 147 DOI: 10.1016/j.catcom.2015.06.011 http://doi.org/10.1016/j.catcom.2015.06.011 .

J.C. Chadwick , G.M.M. van Kessel , O. Sudmeijer . Macromol. Chem. Phys. , 1995 . 196 1431 DOI: 10.1002/macp.1995.021960506 http://doi.org/10.1002/macp.1995.021960506 .

J. C. Chadwick , F.P.T.J. van der Burgt , S. Rastogi , V. Busico , R. Cipullo , G. Talarico , J.J.R. Heere . Macromolecules , 2004 . 37 9722 DOI: 10.1021/ma048108c http://doi.org/10.1021/ma048108c .

J.C. Chadwick , G. Morini , E. Albizzati , G. Balbontin , I. Mingozzi , A. Cristofori , O. Sudmeijer , G.M.M van Kessel . Macromol. Chem. Phys. , 1996 . 197 2501 DOI: 10.1002/macp.1996.021970814 http://doi.org/10.1002/macp.1996.021970814 .

V. Busico , R. Cipullo , P. Corradini . Makromol. Chem. Rapid Commun. , 1992 . 13 15 DOI: 10.1002/marc.1992.030130103 http://doi.org/10.1002/marc.1992.030130103 .

M.C. Forte , F.M.M. Coutinho . Eur. Polym. J. , 1996 . 32 605 DOI: 10.1016/0014-3057(95)00176-X http://doi.org/10.1016/0014-3057(95)00176-X .

Views

Downloads

CSCD

Alert me when the article has been cited

Submit

Tools

Publicity Resources

New Penta-ether as the Internal Donor in the MgCl2-supported Ziegler-Natta Catalysts for Propylene Polymerization

Synergistic Toughening of Polypropylene Alloys Using Core-Shell High-density Polyethylene/Ethylene-Propylene Rubber and Isoprene Rubber Composite Rubber Particles

Dynamic Ionic Crosslinking Polypropylene-based Elastomers with Excellent Mechanical Properties and Antibacterial Performance

Preparation of Polypropylene Nanofibers as a Function of the Thermal Exposure Time of the Polymer in a Melt Electrospinning/Melt Blown Hybrid System

Optically Active Helical Poly(phenyl isocyanide)s Bearing Achiral Benzanilide Pendants: from Controlled Synthesis to Enantioseparation Application

Related Author

Roya Zahedi

Faramarz Afshar Taromi

Seyed Heidar Mirjahanmardi

Mehdi Nekoomanesh Haghighi

Khosrow Jadidi

Roghayeh Jamjah

Hai-Bo Wang

Ang-Xuan Wu

Related Institution

Department of Chemistry, Shahid Beheshti University, 119839-6941, Tehran

Iran Polymer and Petrochemical Institute (IPPI), 514977-1311, Tehran

Department of Polymer Engineering, Amirkabir University of Technology-Mahshahr Campus, 963516-4365, Mahshahr

Department of Polymer Engineering, Amirkabir University of Technology, 15875-4413, Tehran

Department of Chemistry, Amirkabir University of Technology, 15875-4413, Tehran

⁰